Meat cold chain management in Mexican supermarkets
P. Arriaga-Lorenzo,
E. Maldonado-Simán,
R. Ramírez-Valverde,
P. A. Martínez-Hernández,
D. N. Tirado-González,
L. A. Saavedra-Jiménez https://doi.org/10.21323/2414-438X-2024-9-2-100-107
Abstract
The cold chain represents an important opportunity for the food industry to offer food safety and quality of perishable foodstuffs, mainly by maximizing shelf life through limiting bacterial growth. Especially meat products have a short shelf life due to their cold chain requirements. Refrigeration equipment must always be appropriately calibrated and monitored to provide the right temperature and ensure its correct performance. This study aimed to evaluate the cold chain at the retail link in supermarkets of the major commercial chains in Mexico during 2021 and 2022 by recording the surface temperature of pork, poultry, and beef cuts in open coolers. A general linear model was used for the statistical analysis in a completely randomized design. The study considered several factors, such as supermarket, season of the year, position inside the refrigerator, type of meat and environmental temperature. Cold chain breaks were detected in certain seasons of the year, in supermarkets, and even within the refrigerator; there were differences between positions where products were placed. The persistence of these variations in the cold chain represents a public health risk caused by the consumption of foods because a temperature increase can lead to a rise in the microbial load of meat products. Thus, meat cold chain requires integrated logistics management in order to maintain high quality of foods.
Supporting agencies: The article was published as part of the Research Project Code: 23032-C-67 registered at Chapingo Autonomous University, General Directorate of Research and Postgraduate. Acknowledgements: The support of the National Council of Humanities, Science and Technologies of Mexico is gratefully acknowledged
About the Authors
P. Arriaga-Lorenzo
Chapingo Autonomous University
Mexico
Mexico
Pedro Arriaga-Lorenzo, PhD Student, Animal Science Department,
Km. 38.5 Carretera México-Texcoco Chapingo, C.P. 56230, México.
Tel.: +52–595–952–16–21
E. Maldonado-Simán
Chapingo Autonomous University
Mexico
Mexico
Ema Maldonado-Simán, PhD Research — Professor, Animal Science Department
Km. 38.5 Carretera México-Texcoco Chapingo, C.P. 56230, México.
Tel.: +52–595–952–16–21
R. Ramírez-Valverde
Chapingo Autonomous University
Russian Federation
Russian Federation
Rodolfo Ramírez-Valverde, PhD Research — Professor, Animal Science Department
Km. 38.5 Carretera México-Texcoco Chapingo, C.P. 56230, México.
Tel.: +52–595–952–16–21
P. A. Martínez-Hernández
Chapingo Autonomous University
Mexico
Mexico
Pedro A. Martínez-Hernández, PhD Research — Professor, Animal Science Department
Km. 38.5 Carretera México-Texcoco Chapingo, C.P. 56230, México.
Tel.: +52–595–952–16–21
D. N. Tirado-González
National Technological Institute of Mexico
Russian Federation
Russian Federation
Deli N. Tirado-González, PhD Research — Professor, Department of Engineering
Carr. Ags.-S.L.P., km. 18.5, El Llano, Aguascalientes, C.P. 20330
Tel.: +52–449–962–11–00
L. A. Saavedra-Jiménez
Autonomous University of Guerrero
Mexico
Mexico
Luis A. Saavedra-Jiménez, PhD Research — Professor Holder -A, Faculty of Veterinary Medicine and Zootechnics No.2
Carretera Acapulco-Pinotepa Nacional Km. 197. Cuajinicuilapa, Guerrero, C. P. 41940
Tel.: +52–741–414–07–83
References
1. FAO. (2019). The State of Food and Agriculture 2019. Moving forward on food loss and waste reduction. Rome, 2019.
2. Ndraha, N., Vlajic, J., Chang, C.-C., Hsiao, H.-I. (2020). Challenges with food waste management in the food cold chains. Chapter in a book: Food Industry Wastes (Second Edition). Academic Press, 2020. https://doi.org/10.1016/B978-0-12-817121-9.00022-X
3. Porter, S.D., Reay, D.S., Higgins, P., Bomberg, E. (2016). A halfcentury of production-phase greenhouse gas emissions from food loss and waste in the global food supply chain. Science of the Total Environment, 571, 721–729. https://doi.org/10.1016/j.scitotenv.2016.07.041
4. UNEP. (2021). Food Waste Index Report 2021. Nairobi, Kenya, 2021.
5. Arokiyaraj, S., Dinakarkumar, Y., Shin, H. (2024). A comprehensive overview on the preservation techniques and packaging of processed meat products: Emphasis on natural derivatives. Journal of King Saud University — Science, 36(1), Article 103032. https://doi.org/10.1016/j.jksus.2023.103032
6. Wu, J.-Y., Hsiao, H.-I. (2021). Food quality and safety risk diagnosis in the food cold chain through failure mode and effect analysis. Food Control, 120, Article 107501. https://doi.org/10.1016/j.foodcont.2020.107501
7. Ndraha, N., Hsiao, H.-I., Vlajic, J., Yang, M.-F., Lin, H.-T.V. 2018). Time-temperature abuse in the food cold chain: Review of issues, challenges, and recommendations. Food Control, 89, 12–21. https://doi.org/https://doi.org/10.1016/j.foodcont.2018.01.027
8. Mercier, S., Villeneuve, S., Mondor, M., Uysal, I. (2017). Time-Temperature management along the food cold chain: A review of recent developments. Comprehensive Reviews in Food Science and Food Safety, 16(4), 647–667. https://doi.org/10.1111/1541-4337.12269
9. Naqvi, Z.B., Campbell, M.A., Latif, S., Thomson, P.C., Astruc, T., Friend, M.A. et al. (2022). The effect of extended refrigerated storage on the physicochemical, structural, and microbial quality of sous vide cooked biceps femoris treated with ginger powder (zingibain). Meat Science, 186, Article 108729. https://doi.org/10.1016/j.meatsci.2021.108729
10. Qian, J., Yu, Q., Jiang, L., Yang, H., Wu, W. (2022). Food cold chain management improvement: A conjoint analysis on COVID-19 and food cold chain systems. Food Control, 137, Article 108940. https://doi.org/10.1016/j.foodcont.2022.108940
11. Bouzembrak, Y., Klüche, M., Gavai, A., Marvin, H.J.P. (2019). Internet of Things in food safety: Literature review and a bibliometric analysis. Trends in Food Science and Technology, 94, 54–64. https://doi.org/10.1016/j.tifs.2019.11.002
12. Li, X., Zhou, K. (2021). Multi-objective cold chain logistic distribution center location based on carbon emission. Environmental Science and Pollution Research, 28, 32396–32404. https://doi.org/https://doi.org/10.1007/s11356-021-12992-w
13. Hu, L., Xiang, C., Qi, C. (27–29 December, 2019). Research on traceability of cold chain logistics based on RFID and EPC. IOP Conference Series: Materials Science and Engineering. 2019 2nd International Conference on Communication, Network and Artificial Intelligence. Guangzhou, China, 2020. https://doi.org/10.1088/1757-899X/790/1/012167
14. Loisel, J., Duret, S., Cornuéjols, A., Cagnon, D., Tardet, M., Derens-Bertheau, E. et al. (2021). Cold chain break detection and analysis: Can machine learning help? Trends in Food Science and Technology, 112, 391–399. https://doi.org/https://doi.org/10.1016/j.tifs.2021.03.052
15. Arriaga-Lorenzo, P., Maldonado-Simán, E., Ramírez-Valverde, R., Martínez-Hernández, P.A., Tirado-González, D.N., Saavedra-Jiménez, L.A. (2023). Assessment of the cold chain for cuts of beef sold in supermarkets. Revista Chapingo Serie Agricultura Tropical, 3(1), 17–26. https://doi.org/10.5154/r.rchsagt.2023.03.02 (In Spanish)
16. Jofré, A., Latorre-Moratalla, M.L., Garriga, M., Bover-Cid, S. (2019). Domestic refrigerator temperatures in Spain: Assessment of its impact on the safety and shelf-life of cooked meat products. Food Research International, 126, Article 108578. https://doi.org/10.1016/j.foodres.2019.108578
17. Hur, J.I., Kim, J., Kang, M.S., Kim, H.J., Ryu, S., Jeon, B. (2024). Cold tolerance in Campylobacter jejuni and its impact on food safety. Food Research International, 175, Article 113683. https://doi.org/10.1016/j.foodres.2023.113683
18. EUR-Lex (2004). Regulation (EC) No 852/2004 of the European Parliament and of the Council of 29 April 2004 on the hygiene of foodstuffs. Retrieved from https://eur-lex.europa.eu/eli/reg/2004/852/oj Accessed January 15, 2024.
19. Lee, H., Yoon, Y. (2021). Etiological agents implicated in foodborne illness World wide. Food Science of Animal Resources, 41(1), 1–7. https://doi.org/10.5851/kosfa.2020.e75
20. DOF. (2019). Official Mexican standard NOM-213-SSA1-2018, products and services. Outputs processed meat and establishments dedicated to their process. Provisions and sanitary specifications. Test methods. Retrieved from https://www.dof.gob.mx/ota_detalle.php?codigo=5556645&fecha=03/04/2019#gsc.tab=0 Accessed December 17, 2023. (In Spanish)
21. Government of Canada. (2021). General Food Safety Tips. Safe food storage. Retrieved from https://www.canada.ca/en/health-canada/services/general-food-safety-tips/safe-foodstorage.html Accessed December 17, 2023.
22. USDA. (2015). Food Safety. Refrigeration and Food Safety. Retrieved from https://www.fsis.usda.gov/food-safety/safefood-handling-and-preparation/food-safety-basics/refrigeration#:~:text= Accessed December 17, 2023.
23. FDA. (2023). Are You Storing Food Safely? Retrieved from https://www.fda.gov/consumers/consumer-updates/areyou-storing-food-safely Accessed December 17, 2023.
24. Derens-Bertheau, E., Osswald, V., Laguerre, O., Alvarez, G. (2015). Cold chain of chilled food in France. International Journal of Refrigeration, 52, 161–167. https://doi.org/10.1016/j.ijrefrig.2014.06.012
25. Lundén, J., Vanhanen, V., Kotilainen, K., Hemminki, K. (2014). Retail food stores’ internet-based own-check databank records and health officers’ on-site inspection results for cleanliness and food holding temperatures reveal inconsistencies. Food Control, 35(1), 79–84. https://doi.org/10.1016/j.foodcont.2013.06.050
26. Göransson, M., Nilsson, F., Jevinger, Å. (2018). Temperature performance and food shelf-life accuracy in cold food supply chains — I nsights from multiple field studies. Food Control, 86, 332–341. https://doi.org/10.1016/j.foodcont.2017.10.029
27. Laguerre, O., Chaomuang, N. (2020). Closed refrigerated display cabinets: Is it worth it for food quality? Chapter in a book: Research Anthology on Food Waste Reduction and Alternative Diets for Food and Nutrition Security. Engineering Science Reference, 2020. https://doi.org/10.4018/978-1-7998-5354-1.ch005
28. Baldera Zubeldia, B., Nieto Jiménez, M., Valenzuela Claros, M.T., Mariscal Andrés, J.L., Martin-Olmedo, P. (2016). Effectiveness of the cold chain control procedure in the retail sector in Southern Spain. Food Control, 59, 614–618. https://doi.org/10.1016/j.foodcont.2015.06.046
29. Arriaga-Lorenzo, P., Maldonado-Simán, E., Ramírez-Valverde, R., Martínez-Hernández, P.A., Tirado-González, D.N., Saavedra-Jiménez, L.A. (2023). Evaluación de la cadena de frío en cortes de res vendida en supermercados. Revista Chapingo Serie Agricultura Tropical, 3(1), 17–26. https://doi.org/10.5154/r.rchsagt.2023.03.02 (In Spanish)
30. Hernández-Magos, I.P., Maldonado-Simán, E. de J., Arriaga- Lorenzo, P., Martínez-Hernández, P.A., Castrellón-Montelongo, J.L., Santiago-Figueroa, I. (2022). Relevance of cold chain for meat products focusing on pork meat. Current Topics in Agronomic Science, 2(2), 9–13. https://doi.org/10.5154/r.ctasci.2022.06.10a
31. SAS. (2023). On Demand for Academics. Retrieved from https://documentation.sas.com/doc/en/pgmsascdc/9.4_3.4/statug/statug_mixed_syntax01.htm Accessed December 17, 2023.
32. Takemoto, K., Kawahara, M., Atagi, K. (2023). Recurrent guillain-barré syndrome associated with the second episode of Campylobacter jejuni infection. Internal Medicine, 62(20), 1094–22. https://doi.org/10.2169/internalmedicine.1094-22
33. Mir, F., Dar, W., Yaqoob, A., Wani, M., Asmi, R., Wani, M. (2023). Seroprevalence of Campylobacter jejuni infection in common subtypes of Guillain–Barre syndrome in Kashmiri population. The Egyptian Journal of Neurology, Psychiatry and Neurosurgery, 59(1), Article 168. https://doi.org/10.1186/s41983-023-00764-x
34. Talbot, L., Purnell, G., James, S.J., James, C. (2020). Operating temperatures of supermarket frozen retail display cabinets. International Journal of Refrigeration, 117, 81–93. https://doi.org/10.1016/j.ijrefrig.2020.04.017
35. Lundén, J., Vanhanen, V., Myllymäki, T., Laamanen, E., Kotilainen, K., Hemminki, K. (2014). Temperature control efficacy of retail refrigeration equipment. Food Control, 45, 109– 114. https://doi.org/10.1016/j.foodcont.2014.04.041
36. Casanova, C.F., de Souza, M.A., Fisher, B., Colet, R., Marchesi, C.M., Zeni, J. et al. (2022). Bacterial growth in chicken breast fillet submitted to temperature abuse conditions. Food Science and Technology, 42, Article e47920. https://doi.org/10.1590/fst.47920
37. Chaitangjit, P., Ongkunaruk, P. (2019). The study of cold storage and temperature controlled transportation: A case study of a chain restaurant in Thailand. Pamukkale University Journal of Engineering Sciences, 25(9), 1014–1019. https://doi.org/10.5505/pajes.2019.81231
38. Tao, Y., Guo, Y., Li, J., Ye, K., Zhang, Y., Zeng, X. et al. (2023). Effect of temperature fluctuation during superchilling storage on the microstructure and quality of raw pork. Meat Science, 198, Article 109096. https://doi.org/10.1016/j.meatsci.2023.109096
39. Rani, Z.T., Mhlongo, L.C., Hugo, A. (2023). Microbial profiles of meat at different stages of the distribution chain from the abattoir to retail outlets. International Journal of Environmental Research and Public Health, 20(3), Article 1986. https://doi.org/10.3390/ijerph20031986
40. Lopašovský, Ľ., Terentjeva, M., Kunová, S., Zeleňáková, L., Kačániová, M. (2016). Microbiological quality of readyto-eat foods produced in Slovakia. Journal of Microbiology, Biotechnology and Food Sciences, 5(S1), 31–35. https://doi.org/10.15414/jmbfs.2016.5.special1.31-35
41. Odeyemi, O.A., Alegbeleye, O.O., Strateva, M., Stratev, D. (2020). Understanding spoilage microbial community and spoilage mechanisms in foods of animal origin. Comprehensive Reviews in Food Science and Food Safety, 19(2), 311–331. https://doi.org/10.1111/1541-4337.12526
42. Likar, K., Jevšnik, M. (2006). Cold chain maintaining in food trade. Food Control, 17(2), 108–113. https://doi.org/10.1016/j.foodcont.2004.09.009
43. Bruckner, S., Albrecht, A., Petersen, B., Kreyenschmidt, J. (2013). A predictive shelf life model as a tool for the improvement of quality management in pork and poultry chains. Food Control, 29(2), 451–460. https://doi.org/10.1016/j.foodcont.2012.05.048
44. Raab, V., Petersen, B., Kreyenschmidt, J. (2011). Temperature monitoring in meat supply chains. British Food Journal, 113(10), 1267–1289. https://doi.org/10.1108/00070701111177683
45. Nastasijević, I., Lakićević, B., Petrović, Z. (1–4 October, 2017). Cold chain management in meat storage, distribution and retail: A review. IOP Conference Series: Earth and Environmental Science. 59th International Meat Industry Conference. Zlatibor, Serbia, 2017. https://doi.org/10.1088/1755-1315/85/1/012022
46. International Institute of Refrigeration. (2020). The Role of Refrigeration in Worldwide nutrition (2020). 6th Informatory Note on Refrigeration and Food. https://doi.org/10.18462/iir.INfood06.03.2020
47. Gunders, D., (2012). Wasted: How America Is Losing Up to 40 Percent of Its Food from Farm to Fork to Landfill. Natural Resources Defense Council 2012. Retrieved from https://www.nrdc.org/sites/default/files/wasted-food-IP.pdf Accessed January 15, 2024.
48. Morelli, E., Noel, V., Rosset, P., Poumeyrol, G. (2012). Performance and conditions of use of refrigerated display cabinets among producer/ vendors of foodstuffs. Food Control, 26(2), 363–368. https://doi.org/10.1016/j.foodcont.2012.02.002
49. Mercier, S., Mondor, M., McCarthy, U., Villeneuve, S., Alvarez, G., Uysal, I. (2019). Optimized cold chain to save food. Chapter in a book: Saving Food. Academic Press, 2019. https://doi.org/10.1016/B978-0-12-815357-4.00007-9
50. Frank, D., Zhang, Y., Li, Y., Luo, X., Chen, X., Kaur, M. et al. (2019). Shelf life extension of vacuum packaged chilled beef in the Chinese supply chain. A feasibility study. Meat Science, 153, 135–143. https://doi.org/10.1016/j.meatsci.2019.03.006
51. Lipinski, B. (2020). Why does animal-based food loss and waste matter? Animal Frontiers, 10(4), 48–52. https://doi.org/10.1093/af/vfaa039
52. Flanagan, K., Robertson, K., Hanson, C. (2019). Reducing food loss and waste: Setting a global action agenda. WRI Publications, 2019. https://doi.org/10.46830/wrirpt.18.00130
53. James, K. (2023). Climate change impacts on Canada’s food supply cold chain. Chapter in a book: National Collaborating Centre for Environmental Health (NCCEH). Vancouver, BC: NCCEH, 2023.
54. Ashraf, M.W., Alanezi, F. (2022). Sustainable eating futures: A case study in Saudi Arabia. Future of Food: Journal on Food, Agriculture and Society, 11(1), 1–8. https://doi.org/10.17170/kobra-202204136024
Review
For citations:
Arriaga-Lorenzo P., Maldonado-Simán E., Ramírez-Valverde R., Martínez-Hernández P., Tirado-González D., Saavedra-Jiménez L. Meat cold chain management in Mexican supermarkets. Theory and practice of meat processing. 2024;9(2):100-107. https://doi.org/10.21323/2414-438X-2024-9-2-100-107
Views:
493
Email this article 