Nile perch fish nuggets: Partial replacement of fish flesh with sesame hulls and sunroot — Quality assessment and storage stability
https://doi.org/10.21323/2414-438X-2023-8-1-19-25
Аннотация
This study aimed to produce Nile perch fish nuggets by replacing a part of fish flesh with different concentrations of sesame hulls and sunroot to reach the optimal recipe. Chemical, microbiological, and sensory characteristics of nuggets were evaluated during 3 months of frozen storage at –18 °C. According to the obtained data on the chemical composition of raw materials, Nile perch flesh had the highest content of protein (20.21%), sesame hulls contained the highest amount of fat (13.54%), fiber (17.24%) and ash (16.11%), while sunroot tubers had the highest amount of carbohydrates (15.76%). Based on the sensory score, the acceptable replacement ratio for fish nuggets prepared with sunroot (T1) and sesame hulls (T2) was 10% and 7.5%, respectively. Thiobarbituric acid (TBA) analysis at zero time shows that the T1 samples had the minimum value compared to the T2 and control samples. During storage, the TBA levels increased slightly in all samples, but after three months T1 also showed the lowest value. The total plate count (TPC) and psychrophilic bacterial (PSY) count in the samples were affected by the period of frozen storage at –18 °C. The initial TPC and PSY loads were 2.32 and 2.02 log cfu/g for control; 2.24 and 1.72 log cfu/g for T1; 2.30 and 1.47 log cfu/g for T2, respectively. During storage, the values of TPC and Psy slightly decreased. In conclusion, this study succeeded in the replacement of Nile perch fish with sesame hulls and sunroot as new sources to improve the nutritional value and quality characteristics of fish nuggets.
При поддержке: The researchers would like to express their gratitude to the Food Science Department in the Faculty of Agriculture at Cairo University in Egypt for their assistance with this study
Об авторах
T. G. Abedelmaksoud
Cairo University
Египет
Египет
Tarek G. Abedelmaksoud, Assistant Professor, Department of Food Science, Faculty of Agriculture
12613, Giza, Gamaa Street, 1
Tel.: +2–0110–144–12–80
A. S. A. Shehata
Cairo University
Египет
Египет
Ahmed S. A. Shehata, Assistant Professor, Department of Vegetable Crops, Faculty of Agriculture
12613, Giza, Gamaa Street, 1
Tel.: +2–0100–052–95–45
M. A. M. Fahmy
Beni-Suef University
Египет
Египет
Mahmoud A. M. Fahmy, Assistant Professor, Horticulture Department, Faculty of Agriculture
62511, Beni Suef, Salah Salem Street
Tel.: +2–0101–385–16–48
M. E. Abdel-aziz
Cairo University
Египет
Египет
Mohamed E. Abdel-aziz, Associate Professor, Department of Food Science, Faculty of Agriculture
12613, Giza, Gamaa Street, 1
Tel.: +2–0102–777–57–50
A. A. Baioumy
Cairo University
Египет
Египет
Ahmed A. Baioumy, Assistant Professor, Department of Food Science, Faculty of Agriculture
12613, Giza, Gamaa Street, 1
Tel.: +2–0122–838–44–78
Список литературы
1. Antonova, I., Mallikarjunan, P., Duncan, S. E. (2003). Correlating objective measurements of crispness in breaded fried chicken nuggets with sensory crispness. Journal of Food Science, 68(4), 1308–1315. https://doi.org/10.1111/j.1365–2621.2003.tb09644.x
2. Firdevs Dogan, S., Sahin, S., Sumnu, G. (2005). Effects of soy and rice flour addition on batter rheology and quality of deep fatfried chicken nuggets. Journal of Food Engineering, 71(1), 127–132. https://doi.org/10.1016/j.jfoodeng.2004.10.028
3. Maulu, S., Nawanzi, K., Abdel-Tawwab, M., Khalil, H. S. (2021). Fish nutritional value as an approach to children’s nutrition. Frontiers in Nutrition, 8, Article 780844. https://doi.org/10.3389/fnut.2021.780844
4. Nelson, A.L. (2001). High-fibre ingredients: Eagan Press Handbook Series. St Paul, MN: Eagan Press, 2001.
5. Sánchez-Alonso, I., Haji-Maleki, R., Borderias, A. J. (2007). Wheat fiber as a functional ingredient in restructured fish products. Food Chemistry, 100(3), 1037–1043. https://doi.org/10.1016/j.foodchem.2005.09.090
6. Koh, L., Jiang, B., Kasapis, S., Foo, C. W. (2011). Structure, sensory and nutritional aspects of soluble-fibre inclusion in processed food products. Food Hydrocolloids, 25(2), 159–164. https://doi.org/10.1016/j.foodhyd.2010.03.013
7. De Oliveira Filho, P. R. C., Viegas, E. M. M., Kamimura, E. S., Trindade, M. A. (2012). Evaluation of physicochemical and sensory properties of sausages made with washed and unwashed mince from Nile tilapia by-products. Journal of Aquatic Food Product Technology, 21(3), 222–237. https://doi.org/10.1080/10498850.2011.590270
8. De Oliveira Filho, P. R. C. D., Maria Netto, F., Ramos, K. K., Trindade, M. A., Viegas, E. M. M. (2010). Elaboration of sausage using minced fish of Nile tilapia filleting waste. Brazilian Archives of Biology and Technology, 53(6), 1383–1391. https://doi.org/10.1590/S1516–89132010000600015
9. Ninan, G., Bindu, J., Joseph, J. (2010). Frozen storage studies of value-added mince-based products from tilapia (Oreochromis mossambicus, peters 1852). Journal of Food Processing and Preservation, 34(SUPPL. 1), 255–271. https://doi.org/10.1111/j.1745–4549.2009.00379.x
10. Gramatina, I., Zagorska, J., Straumite, E., Sarvi, S. (2012). Sensory evaluation of cooked sausages with legumes additive. International Journal of Nutrition and Food Engineering, 6(10), 915–920.
11. Kurt, Ş., Kilincceker, O. (2012). The effects of cereal and legume flours on the quality characteristics of beef patties. Kafkas Üniversitesi Veteriner Fakültesi Dergisi, 18(5), 725–730. https://doi.org/10.9775/kvfd.2012.6013
12. Akinoso, R., Aboaba, S. A., Olayanju, T. M. A. (2010). Effects of moisture content and heat treatment on peroxide value and oxidative stability of un-refined sesame oil. African Journal of Food, Agriculture, Nutrition and Development, 10(10), 4268–4285 https://doi.org/10.4314/ajfand.v10i10.62908
13. Bonos, E., Kargopoulos, A., Basdagianni, Z., Mpantis, D., Taskopoulou, E., Tsilofiti, B. et al. (2017). Dietary sesame seed hulls utilization on lamb performance, lipid oxidation and fatty acids composition of the meat. Animal Husbandry, Dairy and Veterinary Science, 1(1), 1–5. https://doi.org/10.15761/AHDVS.1000101
14. Kays, S. J., Nottingham, S. F. (2007). Biology and chemistry of Jerusalem artichoke: Helianthus tuberosus L. London: CRC Press/Taylor and Francis Group, 2007.
15. Abedelmaksoud, T. G., Smuda, S. S., Altemimi, A. B., Mohamed, R. M., Pratap-Singh, A., Ali, M. R. (2021). Sunroot snack bar: Optimization, characterization, consumer perception, and storage stability assessment. Food Science and Nutrition, 9(8), 4394–4407. https://doi.org/10.1002/fsn3.2412
16. Baioumy, A. A., Abedelmaksoud, T. G. (2021). Quality properties and storage stability of beef burger as influenced by addition of orange peels (albedo). Theory and Practice of Meat Processing, 6(1), 33–38. https://doi.org/10.21323/2414–438X-2021–6–1–33–38
17. 17.AOAC (Association of Official Analytical Chemists), 2005. Official methods of analysis. 18th edition, Washington DC. VA. 432–440.
18. Daum-Thunberg, D. L., Foegeding, E. A., Ball, H. R. (1992). Rheological and water-holding properties of comminuted turkey breast and thigh: Effects of initial pH. Journal of Food Science, 57(2), 333–337. https://doi.org/10.1111/j.1365–2621.1992.tb05488.x
19. Sallam, K. I., Ishioroshi, M., Samejima, K. (2004). Antioxidant and antimicrobial effects of garlic in chicken sausage. LWT-Food Science and Technology, 37(8), 849–855. https://doi.org/10.1016/j.lwt.2004.04.001
20. Abedelmaksoud, T., Mohsen, S. M., Duedahl-Olesen, L., Elnikeety, M. M., Feyissa, A. H. (2018). Effect of ohmic heating parameters on inactivation of enzymes and quality of not-from-concentrate mango juice. Asian Journal of Scientific Research, 11(3), 383–392. https://doi.org/10.3923/ajsr.2018.383.392
21. Mohsen, S. M., Murkovic, M., El-Nikeety, M. M., Abedelmaksoud, T. G. (2013). Ohmic heating technology and quality characteristics of mango pulp. Journal of Food Industries and Nutrition Science, 3(1), 69–83. https://graz.pure.elsevier.com/en/publications/ohmic-heating-technology-and-quality-characteristicsof-mango-pul
22. Baioumy, A. A., Bobreneva, I. V., Tvorogova, A. A., Abedelmaksoud, T. G. (2021). Effect of quinoa seed and tiger nut mixture on quality characteristics of low-fat beef patties. International Food Research Journal, 28(5), 1038–1047.
23. Okeyo, G. O., Lokuruka, M. N. I., Matofari, J. W. (2009). Nutritional composition and shelflife of the lake victoria nile perch (Lates niloticus) stored in ice. African Journal of Food, Agriculture, Nutrition and Development, 9(3), 901–919. https://doi.org/10.4314/ajfand.v9i3.43017
24. Nikolakakis, I., Bonos, E., Kasapidou, E., Kargopoulos, A., Mitlianga, P. (2014). Effect of dietary sesame seed hulls on broiler performance, carcass traits and lipid oxidation of the meat. European Poultry Science, 78. https://doi.org/10.1399/eps.2014.28
25. Bonnell, A. D. (1994). Quality assurance in seafood processing: A Practical Guide. Springer New York, NY, 1994. https://doi.org/10.1007/978–1–4615–2642–1
26. Al-Hijazeen, M., Lee, E. J., Mendonca, A., Ahn, D. U. (2016). Effect of oregano essential oil (Origanum vulgare subsp. hirtum) on the storage stability and quality parameters of ground chicken breast meat. Antioxidants, 5(2), Article 18. https://doi.org/10.3390/antiox5020018
27. Tokur, B., Polat, A., Beklevik, G., Özkütük, S. (2004). Changes in the quality of fish burger produced from tilapia (Oreochromis niloticus) during frozen storage (–18 °C). European Food Research Technology, 218, 420–423. https://doi.org/10.1007/s00217–004–0879–4
28. Upadhay, A. K., Das, M. (2007). A study on the deep-frozen fish cutlets and fingers prepared from different carp species. Chapter in a book: Fisheries and Fish Toxicology. APH, New Delhi, India, 2007.
29. Lima, D.P., Fuzinatto, M.F., Andretto, A.P., Braccini, G.L., Mori, R.H., Canan, C. et al. (2015). Mechanically separated fillet and meat nuggets of Nile tilapia treated with homeopathic product. African Journal of Pharmacy and Pharmacology, 9(6), 182–189. https://doi.org/10.5897/AJPP2014.4173
30. Günşen, U., Özcan, A., Aydin, A. (2011). Determination of some quality criteria of cold storaged marinated anchovy under vacuum and modified atmosphere conditions. Turkish Journal of Fisheries and Aquatic Sciences, 11(2). https://dergipark.org.tr/en/pub/trjfas-ayrildi/issue/13273/160343
31. Connell, J. J. (1995). Control of fish quality, (4th Ed). Oxford: Fishing News Books, Ltd. https://www.wiley.com/en-us/Control+of+Fish+Quality%2C+4th+Edition-p-9780852382264
32. EOSQC “Egyptian Organization for Standardization and Quality Control” (2005): ES3494 for chilled fish.
33. Allam, A. G. (2001). Studies on storage ability of frozen bolti fish samples. Al-Azhar Journal of Agriculture Research, 14, 101–110.
34. Qiao, Z., Yin, M., Qi, X., LI, Z., Yu, Z., Chen, M., Wang, X. (2022). Freezing and storage on aquatic food: underlying mechanisms and implications on quality deterioration. Food Science and Technology, 42. https://www.scielo.br/j/cta/a/tqJ8QQdK9jxgCPXjYVNJYvF/abstract/?lang=en
35. EOS Egyptian Organization for Standardization (2007): Quick frozen fish product breaded and/or in batter, Part: 3 frozen fish cross slides, Egyptian Organization for Standardization and Quality, Arab Republic of Egypt. No. 889–3. https://www.eos.org.eg/en/standard/2479
Рецензия
Для цитирования:
Abedelmaksoud T.G., Shehata A.S., Fahmy M.A., Abdel-aziz M.E., Baioumy A.A. Nile perch fish nuggets: Partial replacement of fish flesh with sesame hulls and sunroot — Quality assessment and storage stability. Теория и практика переработки мяса. 2023;8(1):19-25. https://doi.org/10.21323/2414-438X-2023-8-1-19-25
For citation:
Abedelmaksoud T.G., Shehata A.S., Fahmy M.A., Abdel-aziz M.E., Baioumy A.A. Nile perch fish nuggets: Partial replacement of fish flesh with sesame hulls and sunroot — Quality assessment and storage stability. Theory and practice of meat processing. 2023;8(1):19-25. https://doi.org/10.21323/2414-438X-2023-8-1-19-25
Просмотров:
675
Послать статью по эл. почте 